Advertisement
Quick Links
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to
Wear eye
instruction
protection
manual
1. SAFETY
Familiarise yourself with the application and limitations of the air hose reel, as well as the specific hazards.
9
WARNING! Disconnect the air hose reel from the air supply before servicing or performing any maintenance.
‰
Maintain the air hose reel in good condition (use an authorised service agent).
9
Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the
9
warranty.
Locate and fix the air hose reel in a suitable working area, ensure that the correct fixings are used to secure the unit to the wall.
9
DO NOT position the hose in direct sun light, or in areas of extreme heat or cold.
8
DO NOT mount inside spray booth/oven.
8
Ensure that there is adequate lighting.
9
WARNING! Ensure maximum air pressure is not exceeded.
‰
WARNING! DO NOT over extend the hose as this will cause the mechanism to malfunction, preventing the hose from retracting.
‰
Keep extended air hose away from heat, oil and sharp edges.
9
Check hose for wear before each use and ensure all connections are secure.
9
Keep the unwound air hose away from wet, damp, oily surfaces.
9
WARNING! Always wear approved eye protection when operating the air hose reel.
‰
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
9
Remove ill fitting clothing. Remove ties, watches, rings, other loose jewellery and contain and/or tie back long hair.
9
Keep children and unauthorised persons away from the working area.
9
DO NOT operate the air hose reel if any parts are damaged or missing as this may cause failure and/or personal injury.
8
DO NOT use the air hose reel for any purpose other than that for which it is designed.
8
DO NOT operate the air hose reel when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT direct air from the air hose at yourself or others.
8
When not in use, ensure the air supply is turned off and tools disconnected. Disconnect from the air supply and retract the hose into
9
case.
WARNING! DO NOT dismantle the hose reel casing. To do so may result in damage to the appliance and/or personal injury and will
‰
invalidate the warranty. Internal maintenance, which will require the opening of the casing, must only be undertaken by an authorised
service agent.
2. INTRODUCTION
Tough, durable design suitable for professional workshops. Controlled, slow rewind mechanism returns the air hose at a safe speed.
Length control allows hose to be extended and positioned at any length. Self layering system provides tangle-free operation. Solid
brass internal spindle for added strength and durability. Fitted with reinforced PVC braided hose. Supplied with heavy-duty swivel
mounted wall bracket and 2m inlet hose.
3.
SPECIFICATION
Model No:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SA93.V3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SA94.V3
Hose Length:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20mtr . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15mtr
Hose Size (ID/OD): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10/16mm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12.5/18.5mm
Maximum Pressure: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 300psi . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 300psi
Hose Type: . . . . . . . . . . . . . . . . . . . . . . . . . . Reinforced Braded PVC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Reinforced Braided PVC
Inlet/Outlet: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3/8"BSPT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1/2"BSPT
4. MOUNTING
4.1.
The mounting bracket MUST be installed on a flat surface. It is recommended that the mounting bracket is installed a minimum of 0.8
metres above the floor level.
4.2.
This reel can be mounted in a vertical or horizontal position. If mounting the reel over 1.8 metres it is advised that the reel is mounted
vertically.
4.3.
If mounting vertically, ensure there is adequate clearance underneath to prevent injury or damage.
4.4.
The reel should be able to swing through 180° unless the locking plate has been installed, see fig.2.
© Jack Sealey Limited
AUTO-REWIND CONTROL AIR HOSE REELS
SA93.V3/SA94.V3
MODEL NO:
Original Language Version
SA93.V3, SA94.V3 Issue:1 06/04/23
Advertisement
Related Manuals for Sealey SA93.V3
Summary of Contents for Sealey SA93.V3
- Page 1 SA93.V3/SA94.V3 MODEL NO: Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions, and properly maintained, give you years of trouble free performance. IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED.
- Page 2 WARNING! DO NOT place fingers or objects in the hose case at any time. ‰ WARNING! DO NOT attempt to fix the product if damaged, return to Sealey service agent. ‰ WARNING! If the hose becomes tangled and will not retract, slowly pull out the hose past the tangled section and then allow the hose ‰...
- Page 3 Parts support is available for this product. Please email sales@sealey.co.uk or telephone 01284 757500 ENVIRONMENT PROTECTION Recycle unwanted materials instead of disposing of them as waste. All tools, accessories and packaging should be sorted, taken to a recycling centre and disposed of in a manner which is compatible with the environment. When the product...