Table of Contents
Advertisement
Quick Links
Installation and operating
manual
ECDh-5
Please read the following instructions carefully before installing heater into service. Trouble
free and safe operating of the unit can only be guaranteed if recommendations and
conditions stated in this manual are respected.
Omega Air User Manual Condensate drain heater ECDh_v1.00 eng
Advertisement
Table of Contents
Summary of Contents for OMEGA AIR ECDh-5
- Page 1 Please read the following instructions carefully before installing heater into service. Trouble free and safe operating of the unit can only be guaranteed if recommendations and conditions stated in this manual are respected. Omega Air User Manual Condensate drain heater ECDh_v1.00 eng...
-
Page 2: Technical Data
ECDh-5 - Installation and operating manual Technical data Type ECDH-5 Voltage 230 V +/-10% Power 5 VA Frequency 50 – 60 Hz Operating temperature range -15°C - 45°C Power interface 2m 3 x 0,75mm Protection class IP67 Mass 0,9 kg... - Page 3 ECDh-5 - Installation and operating manual Operating T1 at connection pipe inside housing T2 at ambient The bottom aluminium part of the heater is in direct contact with ECD housing. The junction transmits 5W of thermal energy from heater to housing. It is recommended to apply thermal conductive paste on the surface of heating element to enhance thermal conductivity.
- Page 4 ECDh-5 - Installation and operating manual Detailed temperature response measured between inside connection pipe (T1) and ambient (T2) is shown on graph. www.omega-air.si...
-
Page 5: Installation
ECDh-5 - Installation and operating manual Installation Part Heating element ECD housing (not included) Junction surface Self tapping screws M5 DIN7500 www.omega-air.si... -
Page 6: Maintenance
ECDh-5 - Installation and operating manual 1. It is recommended to apply thermally conductive paste to the junction surface to enhance heat transfer. 2. Place the heater to the bottom of the drain housing. No washer is needed. 3. Insert three self-tapping screws in to the marked holes. -
Page 7: Troubleshooting
ECDh-5 - Installation and operating manual Troubleshooting Problem Possible cause Solution ECD isn’t Condensate is freezing in pipes Apply additional thermal discharging the before ECD drain. insulation to the heater and inlet condensate and outlet piping. ECD is trying to... - Page 8 OMEGA AIR d.o.o. Ljubljana Cesta Dolomitskega odreda 10 SI-1000 Ljubljana, Slovenia Tel.: +386 (0)1 200 68 00 Fax.: +386 (0)1 200 68 50 E-mail: info@omega-air.si www.omega-air.si www.omega-air.si...